Для европейских автомобилистов instruction manual Webasto уже много лет не является чем-то экзотическим. Ведь очень много автомобилей уже с конвейера идут с такой опцией. Особенно аппарат популярен в Германии, потому что такие предпусковые подогреватели для серийного использования были применены немецкими производителями. Даже название компании Webasto стало таким же нарицательным, как и Ксерокс в своей отрасли.

Due to the fact that our country is located in a fairly cold climate zone, drivers began to put the preheating on their cars independently. Installation does not take up much space, but it helps to treat the power plant and other elements of the car with care.

Content

• 1 Webasto work with the fluid principle
• 2 Air Preheater Varieties
• 3 Ways to launch Webasto
• 4 Using the system
• 5 Positive aspects of using preheating
• 6 Installation rules for preheating installation
• 7 Selection of the unit on the parameters of the car

Webasto work with the fluid principle

The size of the device is relatively small. The five-kilogram device is intended for integration into the fuel supply, cooling and on-board network of the car. The main task of the unit is to preheat the fuel fed into the system, as well as to preheat the cabin of the vehicle.

Installation and initial setup of Webasto should be carried out by experts at the service station.

Remote start is carried out using one of the types of actuators, sometimes referred to as controls. The unit with the help of the work of its own pump through its tubes begins the selection of fuel from the gas tank. After that, flameless combustion (catalytic oxidation) is formed in the closed compartment. By increasing the temperature, special pins made of ceramic material are heated.

WITHхема работы предпускового нагревателя Вебасто

After that, the built-in pump starts to circulate the incoming fuel. Ceramics preheat the liquid flowing from the tank to the combustion chamber. By passing through all the regular channels, including in the area of ​​the cabin heater, the cooling system is heated in a small circle. Reaching a temperature of 40WITH для охлаждающей жидкости, происходит автоматическое отключение.

Если запуск этого аппарата происходит в установленное время, а timer Вебасто еще не отработал весь цикл, то heating can occur up to 80WITHthen decreases to 64WITH. Затем запускается режим поддержания, который отключится лишь по установленному timerу. Придя в гараж или на парковку, водитель садится в теплую машину и запускает прогретый мотор.

The most convenient service for diesel engines that are particularly sensitive to ambient temperature drops. During the ride, Webasto can periodically connect if the air temperature is below +5WITH. WITHредняя трата топлива составляет около 1 л в час.

Air Preheater Varieties

Before you buy and use Webasto, you need to find out which of the existing systems is best suited for your car. After all, there are also air systems. They consume about 0.2 liters of fuel per hour.

Webas species

WITH помощью встроенного насоса закачивается топливо для сгорания. Одновременно идет нагнетание воздуха снаружи авто. В камере сгорания формируется топливовоздушная смесь и происходит сгорание с выделением тепла. Через теплообменник происходит отбор тела. Heated air is supplied to the cabin, and combustion products are discharged through a pipe connected to a silencer.

See also: Why there is no compression in the engine

In contrast to the liquid, which is placed under the hood, the installation of the air heater is carried out in the car. Their sizes are about the same.

Ways to launch Webasto

In order to enable Webasto, there are three main ways: a remote control keyfob, a built-in timer in the launch system, a mobile phone.

Настройка timerа Вебасто

1. Approximate cost of the key fob with remote control запуска составляет около 10 тысяч рублей. Обычно радиус действия позволяет запускать подогрев на расстоянии до 1 км от автомобиля. В настройках водитель может устанавливать точный промежуток времени, в течение которого будут поддерживаться температурные пусковые характеристики. WITHчитается, что запускать Вебасто с помощью пульта более комфортно, чем каждый раз программировать систему с timerом. Ведь нажав кнопку до окончания рабочего времени, можно точно подогреть авто без лишних трат топлива. Однако надо контролировать запустился ли подогрев и не помешали ли старту радиопомехи или другие барьеры. О запуске скажет сигнал с брелока.
2. The cheapest option to enable Webasto is timer. Its cost is about three times less than the remote control. It is mounted in the cabin in the visible part of the panel. To install, you need to synchronize the time of the device with the real time. Then two parameters are programmed: the duration of the heating and the starting time. Most often, the intervals can be set from 10 to 60 minutes.
3. WITHпособ запуска from the phone подразумевает монтаж GSM-блока. Его средняя цена в полтора раза выше от брелокового пуска. WITHигнал может быть отправлен, невзирая на какие-либо препятствия или расстояния. Фактически это можно сделать с любой точки планеты. Модуль отреагирует на WITHМWITH-сообщение, отправленное на номер, присвоенный Вебасто. Максимальное число подключенных телефонных номеров составляет пять штук. Это значит, что не менее пяти водителей могут независимо запускать подогрев мотора. В качестве «продвинутой» диагностики состояния прогрева двигателя можно скачать приложения на смартфон или планшет со всеми популярными операционными системами. Информация будет поступать онлайн на мобильное устройство.

Use of the system

It is necessary to handle the fuel pre-heating unit with sufficient care. It is not recommended to apply a mechanical effect to it, to allow ingress of liquids or other aggressive media into it.

It is strictly not recommended to use the device in a garage without forced exhaust. If there is any extraneous noise or smell from the device, you must immediately turn it off. If it is not possible to do this in the usual way, it is enough to remove the fuse for this.

It is necessary to use fuel only that which is specified in the instruction manual. Once a month, as a preventive measure, it is required to start the device with a cold engine at minimum power. No need to include Webasto in a row several times. The maximum permissible period of continuous operation is 60 minutes.

See also: Why Webasto does not turn on: possible causes

Positive aspects of using preheating

With the installed Webasto system, it is possible to easily start the engine even in extreme cold less than 20 or 30WITH, ведь топливо поступает в систему уже разогретым. Происходит существенная экономия времени на прогрев мотора, ведь делать это можно дистанционно.

Heater Kit

The driver's health is protected, as the cabin is also warming up to an acceptable temperature. It also takes care of the power plant, which spends its life during cold start equivalent to from 100 to 200 km. Preheating reduces emissions, which is a more environmentally friendly system than standard engine heating.

Warming up on a cold engine is more expensive, since the fuel system “eats” with a cold engine much more gasoline or diesel fuel. In this case, the car immediately begins to work on a heated, economy mode.

Installation rules for preheating installation

Not to get to the unscrupulous "masters" for the installation of this equipment will help the certificate, which gives the official representative of the German manufacturer in Russia.

You need to know that the certificate is issued for a limited period, usually it is 1 year. The manufacturer does not offer termless permits.

If there were any problems with the installation or subsequent operation of customers, then no one will extend this document. You also need to know that no one issues perpetual installation permits. The document must have an ending date.

To verify the authenticity of the documents provided, you can refer to the official website of Webasto. The user will receive a numbered warranty card in Russian from the installer company.

The price of products is controlled by the official representatives and a single price is formed for each model. The difference can only be in the cost of work at the service company.

Selection of the unit on the parameters of the car

When choosing a set of equipment it is necessary to focus on the parameters of the vehicle. For machines with a motor up to two liters, four-kilowatt will do. Thermo Top E. If the engine volume is more, then you need to take EVO5.

Next is the selection of the governing body. Depending on the budget, you can choose one of three options. For an inexpensive car, they usually put a minitimer with the ability to install a startup program for the next day. Its installation is carried out on the dashboard.

As a remote start use TermoCall 3. This is a receiver for GSM-signals from phone calls or SMS. It also connects to android applications.

The owner of Webasto can remount it from one of his cars to another. The resource laid by the manufacturer is approximately 9-10 years. Therefore, car owners often transfer the unit to each car they buy, sparing the fuel system and engine each time.

WITHкачать инструкцию Вебасто можно на нашем сайте бесплатно.